-
Diy: Ctr/ek9 Door Trims!!! In 9 STEPS!!
Disclaimer: The following is provided as a GUIDE ONLY, and neither myself nor Ozhonda take any responsibility for the outcomes of someone else doing the following. You follow these steps at your own risk!
Heres my first Diy that im posting up, hated the look of the ugly stock civic door trims and been meaning to retrim in red suede to match my recaros that will be put in. it actually turned out better then i was expecting.
YOU WILL NEED:
-screw drivers
-red suede or material you want trimmed
-scissors
-bond adhesive(max bond)
-strong solid adhesive (megapoxy)
-hack saw
-sandpaper
STEP 1: Take door trim off (total of 5screws on each side)
1x Behind handle
1x arm rest handle
3x holding the trim to the door(not the screws holding the speaker)
STEP 2: Take plastic behind the side mirror off
Once done, pull the trim the pop the plastic pins out, then push up to take the trim off
STEP 3: Take Arm rest off, to do this the little donut things must be cut off.
i used a hack saw to cut them off, cuts really easily.
once all the donuts are cut, the arm rest should pull out.
STEP 4: pull off ugly fabric trim
..than use sandpaper to sand off the hairy stuff left on from the fabric, after give it a good wash with water and dry.
STEP 5: Cut the fabric(red suede) larger then required.
I used "max bond", patiently start from the main surface and stick the fabric on with the adhesive and make sure u spread it evenly to prevent causing lumps. dont stick all at once cuz it may cause wrinkles, start section by section until the fabric is completely stuck on.
TIP: dont use liquidly adhesives as they seem to be soaked into the fabric causing a dark stain. some expensive spray on bonds may be ok.
STEP 6: Let the glue completely dry and cut the required holes.
STEP 7: Stick it back onto the door trim and use a strong adhesive,
i used megapoxy, but any solid bond should be good,
(if you dont want the armrest to be permanently stuck on, i guess it may be possible to use short screws and washers where the donuts were to hold it together)
STEP 8: Let Dry and admirer ur work.
STEP 9: Put the trim back onto your door, same way as u took if off but in reverse lol.
BEFORE
AFTER
The flash from the camera made it look alot lighter, but its actually slightly darker fabric than the recaros.
With Recaros installed
Last edited by simonnowis; 12-03-2009 at 05:17 PM.
-
that is awesome, cheers. im gonna do the same but black suede cause im too povo for recaros
-
thats awesome man!
u even showed alot of ppl just how to take the door trim off lol
can u do mine for me lol? in leather though?
-
heheh hey ricer yeh i can help you do it if u want, if you want urs in red suede i still have alot of fabric left over.
-
Originally Posted by simonnowis
heheh hey ricer yeh i can help you do it if u want, if you want urs in red suede i still have alot of fabric left over.
hahaha i do!
I CANNOT find where the hell yoi buy material, even went to a few trimming places, and they don't seem to just sell material...
I took my passenger door trim off like 3 months ago to do it, and still havent. Everyone complains about there being nothing to lean on...
and i thought they were plastic welds, not rivets ?
Last edited by 1996ek1; 23-02-2008 at 12:22 PM.
-
narh grey leather lol... im boring
will it be much harder using leather or vinyl you think?
-
i think using fabrics that can be stretched abit will work best, thin leather might work, but the thicker type might leave wrinkles.
leather on like a couch, theres always wrinkles so something thiner then that should be fine.
what bout grey suede lol?
every fabric store i went to had other colour suede except red! it was such a pain to find red suede
Last edited by simonnowis; 21-02-2008 at 11:06 PM.
-
-
heheh thanks.
yeh they were plastic pop rivets, but donuts sound cooler hahaha.
is it possible to get plastic pop rivet guns?
-
Originally Posted by simonnowis
heheh thanks.
yeh they were plastic pop rivets, but donuts sound cooler hahaha.
is it possible to get plastic pop rivet guns?
I believe you can buy Plastic pop rivets (not too sure actually)
SPAMMAPS
Carburettor|Nation
that mikey G guy is the biggest shit talker ive ever met..
in the space of 15minutes he sold two sets of wheels. claims a guy under the username DNT-CRY bought them!
-
-
nice work. very straight forward.
pm sent btw
Posting Permissions
- You may not post new threads
- You may not post replies
- You may not post attachments
- You may not edit your posts
-
Forum Rules
|
Bookmarks