-
ED6 weight loss on an all carb diet??
Well the daily duties of my ED6 are now behind her? So I've decided to give the engine a freshen up, lose the emission choking carbs (for some webers or dellorto's) and trim the fat, so to speak.
This thread is purely about pulling stuff of the car and dropping it on the scales. At times it might be a while between posts so feel free to add relevant info.
The project has since changed directions re the power plant..probably should now read.."ED6 weight low on no carb diet" if ya get me.
Rear seat foam 2.8kg
Boot floor 1.0kg
OEM tools 1.8kg
Jack 1.7kg
Parcel Shelf with 6x9's 9.1kg
Parcel shelf pivot pods 1.1kg
Stock spare tyre 13.0kg (165/70-13 Bridgestone RD-116, still looks brand new, anyone know if this is the factory tyre?)
Hatch plastic trim 0.7kg
Rear lower lap belts and anchors 0.8kg
nuts, bolts, plastic clips for the above 0.2kg
Rear seat upper 9.8kg
Rear side window surrounds 0.9kg
Rear lower trims 4.0kg
Rear boot trim (below hatch at the back), t/light access covers, rear blinker access covers, lower hatch strut bolt covers, fuel line cover (middle one under seat), rear lower trim side pocket, rear strut top covers 1.3kg
Rear retractable seat belts 2.1kg
Front window trim upper 0.5kg
Hand bars upper (x3) 0.4kg
nuts, bolts, plastic clips for the above 0.4kg
Floor mats 2.1kg
CD's random crap & rubbish 0.6kg
Honda log book & service manual 0.8kg
Sun visors 0.7kg
Roof lining & map light 0.5kg
Steering wheel cover 0.3kg
Centre console lower 1.7kg
Carpet 4.0kg
Alloy Peddles 0.4kg
CD Player 1.5kg
ECU cover 1.0kg
Front Speakers (6") 1.1kg
A/C Compressor 7.4kg
A/C Compressor Engine Block Bracket 3.2kg
Rest of A/C equipment in engine bay 7.3kg (not including wiring or, tensioner bearing and belt<my car was missing these 2 parts>)
Exhaust heat shield, behind fuel tank 0.4kg
Power steering pump & bracket 3.7kg
Power steering cooler 0.8kg
Power steering lines, from cooler to reservoir inc hardware and reservoir 1.1kg
Approx 1L of hydraulic fluid 1.0kg
Front factory tow points 0.8kg
Carbon canister 0.9kg
Front inner guards 1.4kg
Horn 0.3kg
Window washer bottle (half full) 1.8kg
Rear guard lip protectors 0.3kg
Upper Steering Column shroud + coin tray + Fuse cover (under steering wheel) 0.4kg
Glove Box 0.8kg
A/C Box behind dash 3.1kg
Vent fan box 2.4kg
Heater core vent ducts and box 4.3kg
Rubber deadner behind dash of firewall 3.1kg
Antenna with cable 0.3kg
Bonnet Release Cable & Latch (on Body) 0.4kg
Bonnet Latch (on bonnet) 0.2kg
Window washer hose for rear 0.2kg
Rear mud flaps (small, attached to inner guard and rear bumper) 0.3kg
Number plate mounting bracket (rear) 0.6kg
Power Steering Rack (lower cover) 0.2kg
get your calculators out ftw
Last edited by shake; 23-11-2013 at 08:59 AM.
Reason: updates
-
Rear seat foam 2.8kg
Boot floor 1.0kg
OEM tools 1.8kg
Jack 1.7kg
Parcel Shelf with 6x9's 9.1kg
Parcel shelf pivot pods 1.1kg
Stock spare tyre 13.0kg (165/70-13 Bridgestone RD-116, still looks brand new, anyone know if this is the factory tyre?)
Hatch plastic trim 0.7kg
Rear lower lap belts and anchors 0.8kg
nuts, bolts, plastic clips for the above 0.2kg
-
Rear seat upper 9.8kg
Rear side window surrounds 0.9kg
Rear lower trims 4.0kg
Rear boot trim (below hatch at the back), t/light access covers, rear blinker access covers, lower hatch strut bolt covers, fuel line cover (middle one under seat), rear lower trim side pocket, rear strut top covers 1.3kg
Rear retractable seat belts 2.1kg
Front window trim upper 0.5kg
Hand bars upper (x3) 0.4kg
nuts, bolts, plastic clips for the above 0.4kg
-
Floor mats 2.1kg
CD's random crap & rubbish 0.6kg
Honda log book & service manual 0.8kg
Sun visors 0.7kg
Roof lining & map light 0.5kg
Steering wheel cover 0.3kg
-
32.2
19.4
5.0
So that's 56.6kg thus far whilst not trying too hard...
-
Next step would be remove sound deading from floor
Replace rear side window glass with lexan windows
Fibreglass or carbon fiber bonnet
Light weight biger wheels with slickie tyres
but you also got think about suspension and brakes to go faster
what you using the car for street or full on track work
there many thrends ob here that will help you get more information on going quick
-
There's still heaps more free lightening mods like carpet, center console, air con, power steering etc to go. I'm not too interested I'm lexen or carbon.
I'll probably do some hill climbs and track days.
-
-
Originally Posted by grifty
A/c is a good 20-25Kg.
^ Good to know, plenty more right there.
Centre console lower 1.7kg
Carpet 4.0kg
Alloy Peddles 0.4kg
CD Player 1.5kg
ECU Player 1.0kg
Front Speakers (6") 1.1kg
-
just fuk off the car thats 1000kg right there
-
Weight and gearing then suspension/brakes engine as per the lets talk D series all motor thread.
The life of a 4 stroke engine
It sucks it squeezes it bangs it blows
-
Instead of lexan you can use Perspex. Not quite as light but much lighter than glass, much cheaper.
If you're hill climbing a fair bit a higher FD in your gbox would go awesome. Bang for buck acceleration right thurrr
Posting Permissions
- You may not post new threads
- You may not post replies
- You may not post attachments
- You may not edit your posts
-
Forum Rules
|
Bookmarks